Commitments and Contingent Liabilities |
3 Months Ended | ||||||||||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|
Mar. 31, 2017 | |||||||||||||
Commitments And Contingencies Disclosure [Abstract] | |||||||||||||
Commitments and Contingent Liabilities | Note 13. Commitments and Contingent Liabilities
Litigation In addition to the matters discussed below, Chemours, by virtue of its status as a subsidiary of DuPont prior to the separation, is subject to or required under the separation-related agreements executed prior to the separation to indemnify DuPont against various pending legal proceedings arising out of the normal course of the Chemours business including product liability, intellectual property, commercial, environmental and antitrust lawsuits. It is not possible to predict the outcome of these various proceedings. Except for the PFOA litigation for which a separate assessment is provided in this Note 13, while management believes it is reasonably possible that Chemours could incur losses in excess of the amounts accrued, if any, for the aforementioned proceedings, it does not believe any such loss would have a material impact on Chemours’ consolidated financial position, results of operations or liquidity. With respect to the litigation matters discussed below, including PFOA multi-district litigation (“MDL”), management’s estimate of the probability of loss in excess of the amounts accrued, if any, is addressed individually for each matter. In the event that DuPont seeks indemnification for adverse trial rulings or outcomes for any such matter relating to PFOA, these indemnification claims could materially adversely affect Chemours’ financial condition. Disputes between Chemours and DuPont may also arise with respect to indemnification matters, including disputes based on matters of law or contract interpretation. If and to the extent these disputes arise, they could materially adversely affect Chemours.
In the separation, DuPont assigned its asbestos docket to Chemours. At March 31, 2017 and December 31, 2016, there were approximately 1,900 lawsuits pending against DuPont alleging personal injury from exposure to asbestos. These cases are pending in state and federal court in numerous jurisdictions in the U.S. and are individually set for trial. A small number of cases are pending outside the U.S. Most of the actions were brought by contractors who worked at sites between 1950 and the 1990s. A small number of cases involve similar allegations by DuPont employees or household members of contractors or DuPont employees. Finally, certain lawsuits allege personal injury as a result of exposure to DuPont products. At March 31, 2017 and December 31, 2016, Chemours had an accrual of $41 related to this matter. Chemours reviews this estimate and related assumptions quarterly. Management believes that the likelihood is remote that Chemours would incur losses in excess of the amounts accrued in connection with this matter.
In the separation, DuPont assigned its benzene docket to Chemours. At March 31, 2017 and December 31, 2016, there were 25 and 27 cases pending against DuPont alleging benzene-related illnesses, respectively. These cases consist of premises matters involving contractors and deceased former employees who claim exposure to benzene while working at DuPont sites primarily in the 1960s through the 1980s, and product liability claims based on alleged exposure to benzene found in trace amounts in aromatic hydrocarbon solvents used to manufacture DuPont products, such as paints, thinners and reducers. Through DuPont, Chemours has received a claim by Phillips66 for indemnity and defense for three matters arising at a former DuPont/Conoco Texas site. Phillips66 seeks reimbursement for its settlement and fees in one matter and assumption of the defense in two matters. A benzene case (Hood v. DuPont) was tried to a verdict in Texas state court on October 20, 2015. Plaintiffs alleged that Mr. Hood’s Acute Myelogenous Leukemia was the result of 24 years of occupational exposure to trace benzene found in DuPont automotive paint products and that DuPont negligently failed to warn him that its paints, reducers and thinners contained benzene that could cause cancer or leukemia. The jury found in the Plaintiffs favor awarding $6.9 in compensatory damages and $1.5 in punitive damages. In March 2016, acting on the Company’s motion, the Court struck the punitive award. Through DuPont, Chemours has filed an appeal on the remaining award based upon substantial errors made at the trial court level. Plaintiffs have filed a cross appeal. Management believes that a loss is reasonably possible related to these matters; however, given the evaluation of each benzene matter is highly fact driven and impacted by disease, exposure and other factors, a range of such losses cannot be reasonably estimated at this time.
Prior to the fourth quarter of 2014, the performance chemicals segment of DuPont made PFOA (collectively, perfluorooctanoic acids and its salts, including the ammonium salt) at its Fayetteville plant (Fayetteville, North Carolina) and used PFOA as a processing aid in the manufacture of fluoropolymers and fluoroelastomers at certain sites including: Washington Works (Parkersburg, West Virginia), Chambers Works (Deepwater, New Jersey), Dordrecht Works (Netherlands), Changshu Works (China), and Shimizu (Japan). These sites are now owned and/or operated by Chemours. Chemours recorded accruals of $351 and $349 related to the PFOA matters discussed below at March 31, 2017 and December 31, 2016, respectively. In the fourth quarter of 2016, the Company recorded an approximately $335 accrual related to the PFOA MDL settlement, which is further discussed below. The accruals also include charges related to DuPont’s obligations under agreements with the U.S. Environmental Protection Agency (EPA) and voluntary commitments to the New Jersey Department of Environmental Protection (NJDEP). These obligations and voluntary commitments include surveying, sampling and testing drinking water in and around certain company sites offering treatment or an alternative supply of drinking water if tests indicate the presence of PFOA in drinking water at or greater than the national Health Advisory. A provisional health advisory level was set in 2009 at 0.4 parts per billion (ppb) that includes PFOA in drinking water. In May 2016, the EPA announced a health advisory level of 0.07 ppb that includes PFOA in drinking water. As a result, we recorded an additional $4 in the second quarter of 2016 based on management’s best estimate of the impact of the new health advisory level on the company’s obligations to the EPA, which have expanded the testing and water supply commitments previously established. Based on prior testing, the Company has initiated additional testing and treatment in certain additional locations in and around Chambers Works and Washington Works plants. The Company will continue to work with the EPA regarding the extent of work that may be required with respect to these matters. Drinking Water Actions In August 2001, a class action, captioned Leach v. DuPont, was filed in West Virginia state court alleging that residents living near the Washington Works facility had suffered, or may suffer, deleterious health effects from exposure to PFOA in drinking water. DuPont and attorneys for the class reached a settlement in 2004 that binds about 80,000 residents. In 2005, DuPont paid the plaintiffs’ attorneys’ fees and expenses of $23 and made a payment of $70, which class counsel designated to fund a community health project. Chemours, through DuPont, funded a series of health studies which were completed in October 2012 by an independent science panel of experts (the C8 Science Panel). The studies were conducted in communities exposed to PFOA to evaluate available scientific evidence on whether any probable link exists, as defined in the settlement agreement, between exposure to PFOA and human disease. The C8 Science Panel found probable links, as defined in the settlement agreement, between exposure to PFOA and pregnancy-induced hypertension, including preeclampsia, kidney cancer, testicular cancer, thyroid disease, ulcerative colitis and diagnosed high cholesterol. In May 2013, a panel of three independent medical doctors released its initial recommendations for screening and diagnostic testing of eligible class members. In September 2014, the medical panel recommended follow-up screening and diagnostic testing three years after initial testing, based on individual results. The medical panel has not communicated its anticipated schedule for completion of its protocol. Through DuPont, Chemours is obligated to fund up to $235 for a medical monitoring program for eligible class members and, in addition, administrative cost associated with the program, including class counsel fees. In January 2012, Chemours, through DuPont, put $1 in an escrow account to fund medical monitoring as required by the settlement agreement. The court-appointed Director of Medical Monitoring has established the program to implement the medical panel’s recommendations and the registration process, as well as eligibility screening, is ongoing. Diagnostic screening and testing is on-going and associated payments to service providers are being disbursed from the escrow account. As of March 31, 2017, less than $1 has been disbursed from the escrow account related to medical monitoring. While it is probable that the Company will incur costs related to the medical monitoring program discussed above, such costs cannot be reasonably estimated due to uncertainties surrounding the level of participation by eligible class members and the scope of testing. In addition, under the Leach settlement agreement, DuPont must continue to provide water treatment designed to reduce the level of PFOA in water to six area water districts and private well users. At separation, this obligation was assigned to Chemours, which is included in the accrual amounts recorded as of March 31, 2017. Class members may pursue personal injury claims against DuPont only for those human diseases for which the C8 Science Panel determined a probable link exists. At March 31, 2017 and December 31, 2016, there were approximately 3,500 lawsuits filed in various federal and state courts in Ohio and West Virginia, an increase of approximately 600 over year end 2014. These lawsuits are consolidated in an MDL in Ohio federal court. In the third quarter of 2014, six plaintiffs from the MDL were selected for individual bellwether trials. Litigation and Procedural Posture Prior to Stay of MDL Litigation The six bellwether cases in the MDL were tried, resolved, appealed or otherwise addressed. Two bellwether cases were tried to adverse verdicts, and three were settled for confidential amounts well below the incremental cost of preparing for trial and that were individually and in aggregate immaterial to the Company. The final bellwether matter was removed from the bellwether group when it was determined that the plaintiff did not suffer from the alleged disease. Following the bellwethers, an additional case was tried to an adverse verdict and a fourth trial had commenced but was suspended when a settlement of the MDL was reached. No other claims in the MDL have been settled or resolved during the period presented. Chemours, through DuPont, denies the allegations in these lawsuits and will resume defending the matters vigorously should the settlement not proceed. Settlement of MDL between DuPont and MDL Plaintiffs On February 11, 2017, DuPont entered into an agreement in principle with plaintiffs’ counsel representing the MDL plaintiffs providing for a global settlement of all cases and claims in the MDL, including all filed and unfiled personal injury cases and claims that are part of the plaintiffs’ counsel’s claim inventory, as well as cases that have been tried to a jury verdict (the “MDL Settlement”). A final agreement was executed on March 31, 2017. The total settlement amount is $670.7 million dollars in cash, half of which will be paid by Chemours and half paid by DuPont. DuPont’s payment would not be subject to indemnification or reimbursement by Chemours, and Chemours has accrued approximately $335 million associated with this matter at December 31, 2016. In exchange for payment of the total settlement amount, DuPont and Chemours will receive a complete release of all claims by the settling plaintiffs. The MDL Settlement was entered into solely by way of compromise and settlement and is not in any way an admission of liability or fault by DuPont or Chemours. The MDL Settlement is not subject to court approval; however, the MDL Settlement may not proceed in certain conditions, including a walk-away right that enables DuPont to terminate the MDL Settlement if more than a specified number of plaintiffs determine not to participate. Judicial proceedings related to this action have been stayed pending finalization of the settlement. If the MDL Settlement is terminated or otherwise does not proceed, additional lawsuits may go to trial. Settlement between DuPont and Chemours related to MDL DuPont and Chemours have also agreed, subject to and following the completion of the MDL Settlement, to a limited sharing of potential future PFOA liabilities (i.e., “indemnifiable losses”, as defined in the separation agreement between DuPont and Chemours) for a period of five years. During that five-year period, Chemours would annually pay future PFOA liabilities up to $25 million and, if such amount is exceeded, DuPont would pay any excess amount up to the next $25 million (which payment will not be subject to indemnification by Chemours), with Chemours annually bearing any further excess liabilities under the terms of the separation agreement. After the five-year period, this limited sharing agreement would expire, and Chemours’ indemnification obligations under the separation agreement would continue unchanged. Chemours has also agreed that, upon the MDL Settlement becoming effective, it will not contest its liability to DuPont under the separation agreement for PFOA liabilities on the basis of ostensible defenses generally applicable to the indemnification provisions under the separation agreement, including defenses relating to punitive damages, fines or penalties or attorneys’ fees, and waives any such defenses with respect to PFOA liabilities. Chemours has, however, retained defenses as to whether any particular PFOA claim is within the scope of the indemnification provisions of the separation agreement.
PFOA Summary Chemours has accrued $335 million associated with the MDL Settlement at December 31, 2016. If the MDL Settlement does not proceed, any cases stayed or additional lawsuits may go to trial. An adverse ruling at trial could result in our incurring additional costs and liabilities, which are difficult to estimate beyond accrued amounts and involve significant uncertainty due to the uniqueness of the individual MDL plaintiff’s claims and the defenses to those claims, both as to potential liability and damages on an individual claim basis, and numerous unsettled legal issues, among other factors, such as general versus specific causation, lack of specific fact discovery allowed to date on vast majority of the cases, lack of validation of basic facts associated with plaintiffs and related claims, and the three cases tried to verdict did not inform of the many salient facts and legal issues needed for assessment of the other cases. The trials and appeals of the MDL matters can occur over the course of many years. Significant unfavorable outcomes in a number of cases in the MDL could have a material adverse effect on Chemours’ consolidated financial position, results of operations or cash flows. There could also be new lawsuits filed related to DuPont’s use of PFOA, its manufacture of PFOA, or its customers use of DuPont products that may not be within the scope of the MDL Settlement. Any such new litigation could also result in Chemours incurring additional costs and liabilities. Management believes it is reasonably possible that the Company could incur losses related to other PFOA matters in excess of amounts accrued but any such losses are not estimable at this time.
Five lawsuits, including two putative class actions, were filed against DuPont by area residents concerning the U.S. Smelter and Lead Refinery multi-party Superfund site in East Chicago, Indiana. Three of the lawsuits allege that Chemours is now responsible for DuPont environmental liabilities. The lawsuits include allegations for personal injury damages, damages under the Comprehensive Environmental Response Compensation and Liability Act (“CERCLA”) and damages under the Fair Housing Act. At separation, DuPont assigned Chemours its former plant site, which is located south of the residential portion of the Superfund area, and its responsibility for the environmental remediation at the Superfund site. DuPont has requested that Chemours defend and indemnify it, and Chemours has agreed to do so under a reservation of rights. Management believes a loss is reasonably possible but not estimable at this time. Environmental Chemours, by virtue of its status as a subsidiary of DuPont prior to the separation, is subject to contingencies pursuant to environmental laws and regulations that in the future may require further action to correct the effects on the environment of prior disposal practices or releases of chemical substances by Chemours or other parties. Much of this liability results from CERCLA (often referred to as Superfund), the Resource Conservation and Recovery Act and similar state and global laws. These laws require Chemours to undertake certain investigative, remediation and restoration activities at sites where Chemours conducts or once conducted operations or at sites where Chemours-generated waste was disposed. The accrual also includes estimated costs related to a number of sites identified for which it is probable that environmental remediation will be required, but which are not currently the subject of enforcement activities. At March 31, 2017 and December 31, 2016, the Consolidated Balance Sheets included a liability relating to these matters of $279 and $278, respectively, which, in management’s opinion, is appropriate based on existing facts and circumstances. The time-frame for a site to go through all phases of remediation (investigation and active clean-up) may take about 15 to 20 years, followed by several years of on-going maintenance and monitoring (“OM&M”) activities. Remediation activities, including OM&M activities, vary substantially in duration and cost from site to site. These activities, and their associated costs, depend on the mix of unique site characteristics, evolving remediation technologies, diverse regulatory requirements, as well as the presence or absence of other potentially responsible parties. In addition, for claims that Chemours may be required to indemnify DuPont pursuant to the separation-related agreements, Chemours, through DuPont, has limited available information for certain sites or is in the early stages of discussions with regulators. For these sites in particular, there may be considerable variability between the clean-up activities that are currently being undertaken or planned and the ultimate actions that could be required. Therefore, considerable uncertainty exists with respect to environmental remediation costs and, under adverse changes in circumstances, although deemed remote, the potential liability may range up to approximately $480 above the amount accrued at March 31, 2017. For the three months ended March 31, 2017 and 2016, Chemours incurred environmental remediation expenses of $9 and $7, respectively. Based on existing facts and circumstances, management does not believe that any loss, in excess of amounts accrued, related to remediation activities at any individual site will have a material impact on the Company’s financial position, results of operations or cash flows at any given year, as such obligation can be satisfied or settled over many years. |